How to Make a Car More Fuel Efficient to Run

Economy, Performance, Safety

In this hub, I am going to give scientific advice on fuel economy. I leave it to individual car owners to work out how (or whether) to apply my suggestions. For now, I will only consider external factors, by which I mean things you can do without changing the engine (and without buying into the Water4Gas scam).

Before making any modifications to your car, please realise that safety and performance are not compatible with maximum fuel-economy. A truly economical car would be slow and dangerous on the open road. Everything is a compromise. In fact, you can have any two out of the three, Economy, Performance, Safety, but you can't have all three!

The first step in improving efficiency is to understand the causes of inefficiency and to do this you need to look at your car in a new light.

Car, Mark 1
Car, Mark 1

Here is a car. It has been parked for some time, so it has cooled down to the ambient temperature. It is in thermal equilibrium with its surroundings. It is sitting on level ground, so if you release the brake it will not start to move, i.e. its gravitational potential energy is zero.

In its present state, the car has three possible sources of energy. There is fuel in the tank. Fuel contains chemical energy that can be released by burning. There is a fully charged battery. This also contains chemical energy but in this case it is released by delivering an electric current into a load. The third source? Again, chemical energy, tied up in all the plastics and upholstery. Car fires can be very impressive, but we probably don't want to go there - yet.

OK, now let's get the show on the road. To get the car moving requires either a rocket engine or a way of driving the wheels directly. Rocket engines come into their own in conditions of near-zero friction. If you plan to do most of your driving in rarefied atmosphere and on wet ice, with nobody on your tail, you couldn't do better than rocket power. But let's not go there either.

To turn a stationary car into a moving car, you need to apply a force F for a period of time ΔT. Assuming no friction (for now!) the Impulse, FΔT results in a change in Momentum, ΔMV, where M is the Mass of the car and V is the final Velocity, (Newton's 2nd Law).

To generate the Impulse you have to sacrifice some fuel. What you want in return is Velocity. Therefore you must reduce Mass. Remove from your car everything that is not essential to propulsion: upholstery, seats, trims, dashboard, rear-view mirrors, lights, hi-fi system, cat-basket, the horn, bumpers, children, rear-window stickers, rear window itself. Cut four inches off the gear stick. Oh, and drive in the nude. You get the idea? Lightness = fuel economy.

In addition to the forward momentum of the car, there is also the Angular Momentum of the rotating wheels. This doesn't come free. A rotating wheel has Angular Momentum. A stationary wheel has none. You pay for that Angular Momentum in fuel. But, any rotating wheel of radius r will travel a distance of 2πr (the circumference) in one rotation. It therefore makes sense to minimise the Angular Momentum for any given radius and speed of rotation.

The way to do this is to reduce the mass of the wheel, and in particular, to concentrate the essential mass near the hub and away from the circumference (since the contribution of rotating mass to Angular Momentum is proportional to the square of the radius). Rather like this:

Ideal (good) and Typical (bad) wheel profiles
Ideal (good) and Typical (bad) wheel profiles

Of course, while this will certainly improve fuel efficiency, you'll pay a price in cornering and general roadholding. But isn't it worth it to save a few shekels? It might also be timely to consider how many wheels you really need? [Hint - fewer than four!]

On the subject of cornering: Cornering and acceleration are two sides of the same coin. Both are, by definition, changes of linear and angular momentum. Therefore cornering, like acceleration, is not fuel-free. To maximise fuel economy, you should lock off the steering wheel and only ever drive in a straight line.

Now, having got our car up to speed, Newton's First Law states that it will continue in uniform linear motion unless acted on by an external force. (This First Law is really just a special case of his Second Law. Some would say he was taking the P for even stating it. But others say it defines Inertia, so we'll let him off, this time). So let's try it - knock it out of gear (no engine braking) and see if it rolls on forever. Yes? You're going downhill - that's cheating! No? Welcome to the real world of...

Friction & Air Resistance

Friction first: Friction occurs because nothing is perfectly smooth. Without friction, nothing would stay where it was put, except on a perfectly horizontal surface, and even then, only if there is no breeze. Parked cars would slide down the camber into the gutter. So friction is your friend. But that's static friction, between still surfaces. Dynamic friction between moving surfaces, e.g. your wheel bearings, wastes energy as heat and slows you down. Or it would, if you didn't keep burning a little more fuel to overcome it. One interesting fact is that dynamic friction is fairly constant over a wide speed range. You minimise it through cleaning and lubrication, but you can't eliminate it altogether.

Air resistance: This is a nasty one. Unlike friction, air resistance increases with velocity. Worse, the increase is not linear. It appears linear at low to medium speeds, but at higher speeds the rate of increase also increases. It is not possible to put accurate figures on this, because it depends entirely on what they used to call streamlining - the aerodynamic design of the body. However, if you choose to drive a perfectly spherical car, your air resistance will be proportional to the square of the velocity. Once again, maximum fuel economy is definitely not compatible with safety here. Gliding is fun, but get your pilot's licence first!

Finally:

I've been having a bit of fun here, but the entirely serious points are:

  • Be careful before modifying any designed features
  • Fuel economy without modification is enhanced by:
  • moderate speed
  • gentle acceleration
  • minimal brake use (but stop if you have to!!)
  • gentle steering
  • correct gear selection
  • correct tyre pressures
  • travelling light (no cement sacks in trunk)
  • good maintenance (& lubrication)
  • no roof bars or other 'bolt-ons'
  • daylight driving (no lights)

And of course, fuel economy per head is achieved by carrying passengers!

Happy motoring!

More by this Author


Comments 15 comments

Misha profile image

Misha 8 years ago from DC Area

LOL Good advice, Paraglider :)


Paraglider profile image

Paraglider 8 years ago from Kyle, Scotland Author

Cheers Misha - of corse, the best solution is walk or cycle!


sixtyorso profile image

sixtyorso 8 years ago from South Africa

Very succinctly Put!

I do jog  quite a bit but I have to replace my trainers from time to time and the rubber /Plastic on the soles requires energy to produce. Please don't suggest that I jog barefoot. I might be from Africa but the soles of a Kenyan (keyenesian?) runner I dont have.

Good instructive hub.


Paraglider profile image

Paraglider 8 years ago from Kyle, Scotland Author

Barefoot jogging doesn't appeal. Not does the tradition round here of cycling in sandals! Thanks for the read.


HJ4HHO 8 years ago

Lets just stay home and telecommute! By the way Stop saying water4gas is a scam because it does work. ITs not the ultimate safe, perfect, cool looking self maintaining etc....its skeleton plan that can be adapted for a low price and it does work. I've been using it on my GMC envoy and have improved it from 20mpg to 27-30mpg highway. Now I'm ready to invest in a more sophisticated, safer, self leveling/maintaining system. But for less than $100 I was able to see if it really worked...and it did. This is my defense for the HHO concept. Telecommute saves gas too.


Paraglider profile image

Paraglider 8 years ago from Kyle, Scotland Author

HJ4HHO - If you read everything I've written on the subject, you'll see that I've never denied that optimising the mixture can increase efficiency. But I stand by 2 facts - 1) you can't get a net energy gain from water, and 2) most of the water4gas marketing is scam marketing, full of wild claims, hype and blatant nonsense. It is also potentially dangerous in encouraging people to mess with things they don't understand. Telecommuting is good!


soulsurfer profile image

soulsurfer 8 years ago from South West England

Hi HJ4HHO,

I have to agree with you and Paraglider that telecommuting is THE way to travel. I've been doing it for 25 years now, and I cannot recommend it highly enough. I'm also pleased to learn that you've saved a bit on your gas bills after installing a water4gas system. Seems to be rather less than they claim in their ads though.

Any idea how your Envoy's emissions have changed?

Cheers,

Jim


02SmithA profile image

02SmithA 8 years ago from Ohio

I enjoyed this hub. Less use of the brakes is good, but as you said it's definitely a good idea to stop when it is needed. haha. thumbs up.


Paraglider profile image

Paraglider 8 years ago from Kyle, Scotland Author

02SmithA - Thanks for that!


Evan Hutchinson profile image

Evan Hutchinson 7 years ago from The Dirty South

Also, if you have a stickshift, throw the sucker into neutral and coast as often as possible. I improve my MPG in my 2005 Saturn Ion to about 40 MPG this way.


Paraglider profile image

Paraglider 7 years ago from Kyle, Scotland Author

Evan - yes, that works. Just be careful about doing it on a long downhill!


U Laimo 7 years ago

You guys are total retards wasting your time listening to other retards giving their advise go live life to the full!


Paraglider profile image

Paraglider 7 years ago from Kyle, Scotland Author

U Laimo - you need to learn to distinguish between the serious and the jocular. Good luck.


prettydarkhorse profile image

prettydarkhorse 6 years ago from US

good advice DAVE, walk walk....I always love to walk, it gives me time to appreciate the things around me, it save gas too, LOL

have a good day! Maita


Paraglider profile image

Paraglider 6 years ago from Kyle, Scotland Author

Yes - walking is best, for health and enjoyment!

    Sign in or sign up and post using a HubPages Network account.

    0 of 8192 characters used
    Post Comment

    No HTML is allowed in comments, but URLs will be hyperlinked. Comments are not for promoting your articles or other sites.


    Click to Rate This Article
    working